Vermont Oversize Permits: Vermont Oversize / Overweight Trucking Permits Rules and Requirement
Vermont Oversize permits OR Vermont Overweight Permits are required when a vehicle or its load exceeds the state feet legal size or weight limits and needs to travel on public highways. These permits ensure compliance with safety standards and protect road infrastructure.
Vermont oversize permits phone number: 630-222-5770
Chicago Permit is your trusted partner for obtaining Vermont Oversize Permits, Vermont Overweight Permits, Vermont Overhang Permits, and Vermont Single Trip Permits at low prices with quick processing. Whether you need a Vermont blanket permit, state of Vermont special excess weight permit, or Vermont Annual Permits, we simplify the process with expert support and fast service.
Contact Chicago Permit today to get your permits fast and stress-free!
Vermont oversize regulations
Vermont Legal Dimension Limit
Legal Dimensions for Trucking in Vermont
- Length:
On interstates and designated routes, semi-trailers up to 53 feet in length are permitted, provided the distance from the kingpin to the center of the rear axle does not exceed 43 feet.
Overall length cannot exceed 75 feet.
On roads that are not classified as designated highways, trailer length is restricted to a maximum of 48 feet. - Maximum Width: Maximum allowable width is 8 feet 6 inches.
- Maximum Height: The maximum legal height for vehicles, including the load, is capped at 13 feet 6 inches
Vermont Legal Weight Limit
The maximum allowable gross vehicle weight is up to 80,000 pounds, subject to axle configurations:
Axle weight limits Vermont
- Single axle weight limit:
o 20,000 pounds on designated routes
o 22,400 pounds on non-designated roads - Tandem axle limit:
o 34,000 pounds on designated highways
o 36,000 pounds on other routes - Tridem axle:
o Based on the Federal Bridge Formula (e.g., 34,000 pounds at 8-foot spacing, 42,500 pounds at 9-foot spacing)
Vermont Routine Limit: Vermont Oversize and Overweight Limits
- Length: Up to 99 feet in total length.
- Allowable Overhang: The rear overhang should not be more than one-third of the total length of the load.
- Width: Permitted width extends up to 14 feet 11 inches
- Height: Routine permit height limit is 13 feet 11 inches.
Maximum Weights With Vermont Overweight Permit:
Weight (based on axle configuration and spacing)
- Weight allowances for permits are evaluated on a case-by-case basis by the respective state’s transportation authority.
- Any load surpassing 150,000 pounds gross weight is classified as a superload and must undergo an engineering evaluation, which could require up to 10 business days for processing.
Engineering Review Costs:
- $800 for loads under 150,000 pounds gross
- $2,000 for loads between 150,001 and 200,000 pounds gross
- Higher fees may apply for loads exceeding 200,000 pounds
Vermont oversize permits validity period
To operate legally in Vermont, commercial carriers must secure the appropriate permits based on vehicle size, weight, and registration status. Below is a detailed guide to the validity of all key Vermont trucking permits, including oversize, overweight, superload, IRP, IFTA, TRP, and temporary trip and fuel permits.
Oversize/Overdimensional Permits
- Single Trip Oversize/Overdimensional Permit
▸ Valid for: 10 consecutive days
▸ Covers movement of loads exceeding legal width, height, or length limits for a single trip. - Blanket (Annual) Oversize Permit
▸ Valid for: 1 year (expires with vehicle registration)
▸ Allows repeated travel for specific oversize dimensions on approved routes.
Overweight Permits
- Single Trip Overweight Permit
▸ Valid for: 10 consecutive days
▸ Required when gross weight exceeds standard legal limits. - Annual Overweight Permit
▸ Valid for: 1 year (aligned with vehicle registration)
▸ Authorizes travel for vehicles/load combinations exceeding standard weight limits on designated routes.
Other Specialized Permits
- Route Survey/Engineering Inspection
▸ Required for:
• Loads exceeding 150,000 lbs gross weight
• Special routing for manufactured homes or superloads
▸ Validity: Issued per trip based on load requirements and inspection approval. - Superload Permit
▸ Required for:
• Loads over 150,000 lbs gross weight
• Loads exceeding routine oversize/overweight dimensions
▸ Validity: Determined case-by-case after engineering review.
IRP (International Registration Plan)
- IRP Registration
▸ Valid for: 1 year
▸ Provides apportioned registration for vehicles operating interstate across multiple jurisdictions.
IFTA (International Fuel Tax Agreement)
- IFTA Decal & License
▸ Valid for: 1 calendar year (January 1 – December 31)
▸ Required for carriers operating in multiple jurisdictions with a qualifying weight (26,000 lbs+ or 3+ axles).
Additional Permits - Trip Permit
▸ Valid for: Typically 3–10 days
▸ Allows temporary operation of unregistered vehicles in Vermont. - Fuel Permit
▸ Valid for: Typically 3–10 days
▸ Required for carriers without IFTA credentials traveling through Vermont.
Key Notes - Permits must be carried during transport and presented upon request.
- Annual permits align with vehicle registration expiration dates.
- Seasonal restrictions (frost laws, construction zones, holiday travel limits) may impact permit validity or travel conditions.
Operating Time Vermont:
Movements are allowed from half an hour before sunrise until half an hour after sunset. Loads that exceed 10 feet 6 inches in width, 100 feet in overall length, or 108,000 pounds in gross weight are not allowed to travel on weekends. Additionally, from July 1 through Labor Day, Friday afternoon travel restrictions may apply. Loads that are only overweight (not overdimensional) are not limited to daylight travel only and may move depending on traffic and road conditions
Restricted Travel Vermont:
Permits for loads that neither originate nor terminate in Vermont are only issued if traveling through Vermont is the most direct route. The state generally avoids issuing permits for through traffic that does not involve pick-up or delivery within its borders. Unless otherwise posted, any load over 90,000 pounds, wider than 10 feet, taller than legal height, or longer than 75 feet must not exceed 45 miles per hour on Vermont state highways. No travel is permitted on public holidays for loads exceeding 10 feet 6 inches in width, 100 feet in length, or 108,000 pounds in gross weight
Seasonal Load Restrictions
Many states and provinces, including Vermont, enforce seasonal load restrictions during frost or thaw periods. These rules vary depending on the nature of the load and weather conditions.
During spring thaw, melting periods, or rainy weather, the Vermont Agency of Transportation may post weight restrictions along certain state highways. Permits do not override these posted limits, and operators must comply with all posted signage.
Oversized Tire Regulations
All tires must be in good working condition, properly inflated, and have a minimum tread depth of 2/32 inches.
Vehicles with a Gross Vehicle Weight Rating (GVWR) or Gross Combined Weight Rating (GCWR) over 26,000 pounds may be required to use tire chains during winter conditions.
Chaine Requirements in Vermont
- Single-drive axles: On single-drive axle configurations, chains are required on one tire on each side during hazardous conditions.
- Tandem-drive axles: Either two tires on the same side of the main drive axle or one tire per side on both drive axles must be chained, depending on configuration.
Road and Bridge Restrictions
Vermont follows the Federal Bridge Formula to determine weight limits and applies bridge-specific restrictions where necessary. Road restrictions may involve, but are not limited to:
- Passing through active construction zones
- Ignoring warning signals or traffic control devices in work areas
- Failing to yield to emergency responders or law enforcement
- Using handheld electronic devices while driving in work zones
Penalties for handheld device use in work zones:
- First offense: $100 to $200 fine and 2 points on the license
- Subsequent offenses: $250 to $500 fine and 5 points
Amber Light Permit Rules
Vehicles transporting oversize loads must be equipped with amber warning lights mounted on the roof. These are used to alert surrounding traffic and improve visibility for large or extended loads.
Escort requirement
- Length: One escort is mandatory when overall length reaches or exceeds 80 feet.
- Overhang: If rear or front overhang is 15 feet or more, one escort is required.
- Width: A minimum of one escort vehicle is necessary for loads that are 12 feet wide or more.
- Height: Escorts are generally not required for height; however, loads above 14 feet are heavily restricted and may be subject to special conditions.
Vermont Banners, Lighting & Flage Requirement
For all oversize/overdimension (O/D) movements, an “Oversize Load” sign is required at the front of the power unit and at the rear of the trailer or load. Red or orange flags, at least 18 inches square, must be placed on each corner or extremity of loads or vehicles that exceed standard width or length. For overlength or rear overhang exceeding 4 feet:
- If the rear overhang is under 2 feet in width, one red or orange warning flag must be displayed.
- For rear overhangs measuring 2 feet or wider, two warning flags must be positioned for proper visibility
Amber flashing lights mounted on the towing vehicle are required when the load exceeds 12 feet in width or 80 feet in length. These lighting and marking rules do not apply to loads that are only overweight.
Vermont Oversize /Overweight Fee structure
Vermont offers a variety of vehicle and transportation permits, each with its own fee depending on the type and usage. Below is a breakdown of key permit types and their current associated costs:
- Single Trip Permit: $35.00 per trip
- Single Trip Overlength Permit: $25.00 per trip
Route Survey & Engineering Inspection Fees
- For manufactured homes requiring special routing: $300.00
- For any size load or those under 150,000 lbs gross weight: $800.00
- For loads between 150,000 lbs and 200,000 lbs gross weight: $2,000.00
- For loads between 200,001 lbs and 250,000 lbs gross weight: $5,000.00
- For loads exceeding 250,000 lbs gross weight: $10,000.00
- If an inspection exceeds 8 hours, an additional fee of $60.00 will be charged per hour for each hour beyond the 8-hour limit.
Blanket Permit Pricing
- Initial blanket permit: $100.00
- Each additional permit: $5.00, up to a maximum of 1,000 permits
- Validity: Expires upon expiration of the vehicle’s registration
Chicago Permit is the single STOP for all Oversize / Overweight permits with one easy-to-use application.
Frequently Asked Questions
Vermont oversize permits can be obtained online through our website comparetransportll.com or by calling us at 630-222-5770
In Vermont, a load can be up to 8 feet 6 inches wide on most roads without needing a special oversize permit. Anything wider requires a permit.
Vermont requires permits for vehicles or loads exceeding legal size or weight limits. This includes overwidth, overheight, overlength, and overweight loads. Permits must be obtained before travel, and specific escort or routing rules may apply.
Yes, Vermont requires temporary trip permits for commercial vehicles that are not registered with the International Registration Plan (IRP).
The cost of a Vermont overweight permit depends on the total weight and number of axles. Generally, it starts around $35 and increases based on the load configuration.
Vermont oversize permits can be obtained online through our website comparetransportll.com or by calling us at 630-222-5770
Overweight permits in Vermont typically start from $35, with fees increasing based on the excess weight and axle count.
The base fee for a Vermont oversize permit is approximately $35–$45, but this may vary depending on dimensions and route.
Applications for Vermont oversize permits can be submitted online via our website comparetransportll.com or by calling us at 630-222-5770
In Vermont, any vehicle or load over 8 feet 6 inches wide, 13 feet 6 inches high, or 75 feet long (depending on vehicle type) is considered oversize and requires a permit.
Generally, oversize loads are allowed to move during daylight hours only, from 30 minutes before sunrise to 30 minutes after sunset. Night travel is usually restricted unless special permission is granted.
The phone number for assistance is 630-222-5770.
Truck laws in Vermont cover size, weight, axle spacing, and safety requirements. These include needing permits for oversize/overweight loads, obeying travel time restrictions, and using escorts when required.
The maximum gross vehicle weight rating (GVWR) allowed on Vermont highways without a permit is 80,000 pounds. Heavier loads must obtain an overweight permit.
You can obtain a Vermont trip permit online Compare Transport LLC, which simplifies the process and ensures compliance.
A Vermont weight permit authorizes trucks to haul loads that exceed the standard weight limits. It includes axle spacing, total weight, and route specifications.
Yes, you can get Vermont oversize permit online by calling us at 630-222-5770.
A load is considered oversized in Vermont if it exceeds 8’6” in width, 13’6” in height, or 75 feet in overall length. Vehicles carrying such loads must have a permit.
Without a permit, the standard gross vehicle weight limit in Vermont is 80,000 pounds. Exceeding this requires an overweight permit.
To get your Vermont oversize permits fast and at competitive prices, contact Compare Transport LLC at (630) 222-5770. Their experienced team will handle all permit types across the U.S. and Canada.
You can log in to manage your Vermont oversize permit through Our website comparetransportll.com
The cost for a Vermont oversize permit ranges from $35 to $50, depending on the size of the load and route requirements.
